Golf III/Jetta III ‘93-’99 & Cabriolet ‘95-’02
PISTON AND RINGS
COOLING SYSTEM
PISTON RING SETS (STANDARD)
2.0 L 4 cylinder
#SN10862 . . . . . . . .$79.95
1.9 TD diesel and TDI (EACH)
#SN17823 . . . . . . . .$39.95
VR6
#SN13367 . . . . . . . .$189.95
PISTON SETS
We sell top-quality OEM piston sets from Mahle, Cofap and Kolbenschmidt. Don’t cut corners when replacing pistons. Buy the best.
2.0 L 4 cylinder
#SN18776 . . . . . . . .$299.95
1.9 TD (not TDI)
#SN18701 . . . . . . . . $174.95
1.9 T TDI
#SN18777. . . . . . . . . $799.95
VR6
#SN18778. . . . . . . . . $149.95
Note: VW sells their pistons and rings per cylinder--not in complete sets. So when the dealer quotes you $342.00, that’s $342.00 EACH!!! Ours cost much less and are the same quality and you won’t have to take out a 2nd mortgage to buy them!
ENGINE BEARINGS
Main Bearing
2.0/TDI
Std. #SN1577 . . . . . . . .$46.95
.010 over #SN1578 . . . . . . . .$52.95
.020 over #SN1579 . . . . . . . .$52.95
VR6
Std. #SN18779 . . . . . . . .$69.95
Rod Bearings
2.0
Std. #SN1601 . . . . . . . .$21.95
1.9 DSL/TDI
Std. #SN17824 . . . . . . . .$69.95
VR6
Std. #SN18780 . . . . . . . .$54.95
is an absolute must when you’re rebuilding an engine to protect new bearings and journals. Using regular oil doesn’t do the job, unless you’re extremely careful and pre run your oil pump before start-up. Don’t wreck your freshly rebuilt engine by starting it up “dry”.
#SN18949. . . . . . . . . . . $7.95
OIL COOLERS
These occasionally fail and fool you into thinking you have a blown head gasket by mixing oil and antifreeze together. If you find oil in your coolant or vice-versa but no other symptoms of a blown head gasket, you oil cooler may be bad. Also, if you spin a bearing or chew up a piston and get metal shavings in you oil, you should definitely replace the cooler, as there is no 100% effective way to flush all the shavings out. Fits all 2.0 L gas, and 1.9 L diesel and TDI.
New #SN15359 . . . . . . . .$109.95
Recycled #SN33346 . . . . . . . .$45.00
WATER PUMPS
2.0 L 4 cylinder and 1.9 L TDI
1. Pump
#SN5013 . . . . . . . .$35.00
2. Gasket
#SN1327 . . . . . . . .$1.80
3. Water pump housing
#SN1326 . . . . . . . .$37.50
4. O-ring
#SN1333 . . . . . . . .$1.00
5. Thermostat
80° C #SN1329 . . . . . . . .$8.95
87° C #SN1330 . . . . . . . .$8.50
TDI 87° C #SN17960 . . .$13.95
-
6. Thermostat housing
#SN18790 . . . . . . . .$9.95
VR6
1. Pulley #SN18621 . . . . . . . .$10.95
2. Water pump #SN13070 . . . $84.95
3. Gasket #SN15559 . . . . . . . $1.50
Auxiliary water pump (not pictured). These are electric.
‘93-95
#SN15015 . . . . . . . $149.95
‘96-99.5
#SN18341 . . . . . . . $135.99
Thermostat (not pictured)
80° C #SN13298 . . . . . . . $22.95
Used Parts Too . . . .CALL!!!!!!
COOLING FAN
4 cylinder (gas and diesel) ‘93-99.5
#SN14654 . . . . . . . $139.95
VR6 ‘93-99.5
#SN18020 . . . . . . . $259.95
Thermoswitch for cooling fan‘ 93-94.5
#SN03230 . . . . . . . $15.95
VR6 94.5-99.5
#SN16107 . . . . . . . $19.95
Yours may be a different part number and/or look different.
WATER FLANGE
These water flanges are located on the drivers side of the cylinder head. They’re made of plastic, and sooner or later they will start to leak. If you’re losing coolant, check the flange - it is likely the culprit.
2.0 L 4 cylinder ‘93-99.5
Manual trans. #SN15624 . . . . .$9.99
Automatic trans. #SN15625 . . .$12.95
TDI ‘97-99.5
Manual trans. (end) #SN15611 . .$9.95
VR6 all #SN15629 . . . . . . . $29.95
OVERFLOW TANK
These have a built in coolant-level sensor. If your coolant light is flashing but the level checks out OK, the sensor may be bad. The only solution is to replace the tank.
4 cylinder (gas and diesel)
New #SN12151 . . . . . . . $24.95
Recycled #SN34167 . . . . . . . $18.00
VR6
New #SN15631 . . . . . . . $68.95
Recycled #SN37619 . . . . . . . $30.00
Cap, all #SN12969 . . . . . . . $6.95