PartsPlace
inc.
R-47
Auburn Hills, MI 48326
Fax: (248) 373-5950
2300 N. Opdyke
(248) 373-2300
[13]
Auxiliary Air Valve,
works like keeping your foot on the
"gas" to let it warm up. When you step on
the "gas" you are actually stepping on the
air
. The accelerator cable only opens the
air valves (throttle valves) so pumping
the "gas" before you turn over the car
does nothing but give you exercise.
To make the car race with your foot off
the "gas" you have to give it some air. The
Auxiliary Air Valve is just a "U" -shaped
hose around the throttle valves. To give it
extra air VW
®
put a rotary valve in the line
that times out and closes after the car warms up so it won't
race. Simple!
They clog with junk and burn out - our recycled ones are
the best value.
All VW
®
thru ‘81
#SN11520
(New)
..................................................
89.
9 5
#SN11521
(Recycled)
............................................
30.
0 0
All VW
®
‘82-84
#SN9178
(New)
....................................................
99.
9 5
#SN33379
(Recycled)
............................................
35.
0 0
All VW
®
‘85-87
#SN11519
(New)
..................................................
84.
9 5
#SN30153
(Recycled)
............................................
45.
00
[8]
Air Flow Meter -
We have
good used meters (they measure the amount of air
coming into engine so the brain can calculate the cor-
rect amount of fuel to use) Bosch currently lists over
25 different part numbers - Call us with yours -
SAVE
$$$
[9] Relay-Fuel Pump
These relays supply electricidad to
your fuel pump or pumps. This lit-
tle device will keep you from start-
ing if it malfunctions. We have new
and recycled from
$
15.
00
ea. Get the
part number off the relay so we’re
sure we get you the right one!
Fuel Injection
[11] The Thermo Switch
has a
timer and bi-metallic element. It is heated
by the engine water and depending upon
how hot it is, it allows electricity to flow
from 2 to 20 seconds to open the cold start
valve. It should time out; jumper it to
check the system. Replace if defective.
Our recycled thermo switches work per-
fect.
All VWs
®
1977-87
#SN3047
. . . . . . . . . . . . .
89.
95
#SN33982
(Rec.)
. . . . . . .
25.
00
[12] Warm-up
Regulator
This acts like a choke. It
makes the car run richer,
it picks up heat from the
block and from an inter-
nal bi-metallic heater.
What it does is apply
fuel pressure to the top
of the fuel distributor pin, pushing it down, making it
run rich. If the car starts, but runs poor until it warms
up, it could be this.
‘77-83
#SN14269
(Reman.)
......................
139.
9 5
#SN30152
(Recycled)
..........................
75.
0 0
‘84-87
#SN14416
(Reman.)
..........................
139.
0 0
#SN9491
(Recycled)
........................
89.
0 0
[10] Cold Start Valve,
sometimes called the
5th injector. This thing sprays a squirt of gas 2 to 20 sec-
onds to get the car to kick over and start. (The gas does not
go through the fuel distributor, so sometimes the car will
start and run for 5 or 10 seconds, then start again and again
and again, but won't run for more than 20 seconds.) It's
running on gas from the 5th injector. Your problem is that
the fuel distributor is clogged. The cold start valve has
constant fuel under pressure, and the electric wire from the
thermo time switch is just telling it to fire. If you put 12
volts to the cold start valve and it does not fire, and you
have fuel pressure, replace it.
Cold Start Valve
Most VW
®
‘77-89
#SN11516
(New)
......................................
115.
9
5
#SN33146
(Recycled)
.................................
50.
0 0
[17]
The ECM or Computer,
or “Brain" is the computer that takes all the input
from the various sensors and calculates the proper
fuel/air settings. If yours fails - don’t buy one from
the dealer - you’ll have to cancel your vacation!
Call us with the part # - your car will snap back to
life and your wallet will thank you! Save hundreds!
From $100 each, Recycled!
[
15
] The Oxygen Sensor,
or as it’s more uncommonly known - the
Lambda
Sensor
,
sniffs the oxygen content in
the exhaust gas and signals the fuel injection to
enrich or lean depending on the situation. These
devices do require periodic replacement (usually
every 30,000 miles) we stock a wide variety for
all VWs
®
.
From
$
49.
95
each.
Idle Air Stabilizer Valve
is used to control idle speed on later models (most ‘88 on)
VWs
®
and CIS-E/Motronic systems. If your idle “hunts" up
and down, your idle or stabilizer is probably bad. We have
new and recycled units available.
Call with your part # off yours. There are many others!
Golf
®
/Jetta
®
8V ‘85-87 and 16V ‘86-89 (three prungs)
#
SN
4510
(New)
. . . . . . . . . . . . . . . . . . . . .
219.
9 5
#
SN
37341
(Reman.)
. . . . . . . . . . . . . . . . . .
149.
9 5
#
SN
35882
(Used)
. . . . . . . . . . . . . . . . . . . . .
95.
0 0
Golf
®
/Jetta
®
8V ‘88-92 (two prungs)
#
SN
33523
(New)
. . . . . . . . . . . . . . . . . . . .
199.
9 5
#
SN
37340
(Used)
. . . . . . . . . . . . . . . . . . . . .
80.
0 0
Golf
®
/Jetta
®
/Passat
®
16V ‘90-92, most
Golf/Jetta/Corrado/Passat VR6 ‘92-95
#
SN
14060
(New)
. . . . . . . . . . . . . . . . . . . .
269.
9 5
#
SN
37349
(Reman.)
. . . . . . . . . . . . . . . . . .
229.
9 5
#
SN
3235
(Used)
. . . . . . . . . . . . . . . . . . . . . .
80.
0 0
Golf
®
/Jetta III
®
‘93-95, Cabriolet ‘95-02 2.0L, Passat
®
2.0L ‘95-97
#
SN
16198
(New)
. . . . . . . . . . . . . . . . . . . .
229.
9 5
#
SN
38710
(Used)
. . . . . . . . . . . . . . . . . . . .
115.
0 0
Differential Pressure
Regulator
is found on ‘85-93 VWs
®
with
CIS-E or CIS-Motronic injec-
tion. This electromagnetic
device makes small adjustments
to the fuel mixture by altering
pressure to the lower half of the
fuel distributor. Using signals
form the O
2
sensor, coolant temp
sensor(s) and a few other sen-
sors, the F. I. brain tells the differential pressure regulator to
enrich or lean out the fuel mixture. If yours is bad, the car will
run roughly or may not run at all. Test it using the procedure in
the Bentley Manual.
#
SN
35625
‘85-89 (CIS-E)
65.
0 0
#
SN
36868
‘90-93 (CIS-Motronic)
100.
0 0
IRREGULAR
IDLE..
Save up to
$
500!
Remanufactured Units Available
Count the Prungs!
Call for other applications.
BOSCH lists 10 different part numbers!
Our recycled valve
should work great for years!
[14]
The Throttle Plate,
These
flappers are simple open - close devices - if they get
sticky try cleaning area with Gum-out! Later throttle
bodies incorporate an electronic throttle position sen-
sor. Sometimes these go bad. Call us - we’ve got good
recycled throttle bodies in stock.
[16]
The Frequency Valve,
is a little pump to enrich the fuel/air mixture. It is
only found on cars from 1981-on.
The Valve works in conjunction with the Oxygen
Sensor and adjusts the amount of fuel.
Our recycled
part works fine.
All ‘81-87 VWs
®
#SN5727
New
. . . . . . . . . . . . . . . . .169.
9 5
#SN11523
Recycled
. . . . . . . . . . . . . . . .65.
0 0
