Golf III/Jetta III ‘93-’99 & Cabriolet ‘95-’02
STEERING
All Golfs, Jettas and Cabrios manufactured from 1993 onward have power assisted rack and pinion steering. Two different manufacturers, ZF and TRW, supplied steering racks and the rods. Unfortunately the two are not interchangeable. When ordering steering parts, you must know which steering rack you have. The easiest way to tell is to pop the hood and look at the rack. If the rack is smooth, it is made by TRW. If the rack has a “waffle” pattern in the casting it is made by ZF.
(See pictures below).
POWER STEERING RESERVOIR
4 cylinder, all ‘93-99.5, Cabrio ‘95-02
New #SN16767 . . . . . . . .$39.95
Recycled #SN39009 . . . . . . . .$20.00
VR6, all ‘93-99.5
New #SN14198 . . . . . . . .$59.95
Recycled #SN38497 . . . . . . . .$25.00
POWER STEERING HOSES
When these fail, you’ll notice that you either lose power assist to the steering, you’re always adding power steering fluid, your engine compartment is an oily mess or all of the above. There are three main hoses in the system, completing a “circuit” between the steering, the rack and the reservoir. Call with your needs, we have new hoses and good recycled hoses available.
Return line (from the rack to reservoir)
#SN18832 . . . . . . . .$29.95
Pressure line (from pump to rack)
2.0 L Golf/Jetta
#SN15464 . . . . . . . .$89.95
VR6 Golf/Jetta
#SN15466 . . . . . . . .$275.00
TDI Golf/Jetta
#SN15465 . . . . . . . .$174.95
Cabrio (auto trans)
#SN15465 . . . . . . . .$174.95
Cabrio (manual trans)
#SN18833 . . . . . . . .$174.95
Suction line (from reservoir to pump)
#SNXXXX . . . . . . . .CALL
BRAKES
FRONT CALIPERS
4 cylinder, all (2.0 L and TDI)
New #SN14156 . . . . . . . .$109.95
Left
Reman #SN40014 . . . . . . . .$59.95
Recycled #SN35578 . . . . . . . .$25.00
Right
Reman #SN40012 . . . . . . . .$59.95
Recycled #SN35577 . . . . . . . .$25.00
VR6
‘93-95
Left New #SN14157 . . . . . . . .$89.95
Right New #SN14500 . . . . . . . .$119.95
‘96-97
Left New#SN18834 . . . . . . . .$189.95
Right New #SN18835 . . . . . . . .$189.95
‘98-99.5
Left New #SN18836 . . . . . . . .$149.95
Right New #SN18837 . . . . . . . .$149.95
TECH TIP: A “brake job” is a big deal at the dealer, but changing front rotors and pads is less than a 2 hour job for the D.I.Y.er, less if you’re fast, and JUST AS GOOD!!! Could save you $1,000!!
TIE ROD BOOTS
(Left & Right are the same)
TRW rack #SN15754 . . . . . . . .$12.95
ZF rack #SN15690 . . . . . . . .$12.95
TIE RODS
TRW, ‘93-99.5
Left #SN13608 . . . . . . . .$49.95
Right #SN13609 . . . . . . . .$49.95
ZF, ‘93-99.5
Left #SN13346 . . . . . . . .$59.95
Right #SN13347 . . . . . . . .$59.95
POWER STEERING PUMP
If your pump groans or leaks or can no longer provide adequate steering assist, it’s time for a new pump. We have new or excellent recycled pumps available.
4 cylinder, 93-95
New #SN15458 . . . . . . . .$219.95
Recycled #SN37367 . . . . . . . .$89.95
VR6, ‘93-99.5
Reman #SN15461 . . . . . . . .$274.95
Recycled #SN39008 . . . . . . . .$99.99
Power Steering Pump Rebuild Kits . . .Call!
REAR STUB AXLES
If a rear wheel bearing goes bad, you will usually have to replace the stub axle as well. Examine them for scoring any time you remove the rear drums (or discs).
Drum brakes (w/o ABS)
Left/Right
New #SN16170 . . . . . . . .$39.95
Reman #SN13520 . . . . . . . .$19.50
Disc brakes (w/o ABS)
Left
New #SN33382 . . . . . . . .$89.95
Reman #SN12555 . . . . . . . .$65.00
Recycled #SN2116 . . . . . . . .$40.00
Right
New #SN13526 . . . . . . . .$89.98
Reman #SN37116 . . . . . . . .$65.00
Recycled #SN31180 . . . . . . . .$40.00
Disc brakes (w/ ABS)
Left New #SN33382 . . . . . . . .$89.95
Right New #SN13526 . . . . . . . .$89.98