Golf 99.5-08/Jetta 99.5-08/New Beetle 98-08
Air Flow Meters
Also called a “mass air sensor”, these devices are supposed to measure the amount of air the engine is taking in to correctly calculate how much fuel should be injected. Without an accurate measure, the engine will run poorly or not at all. We’ve seen a lot of these fail in the newer VW’s. Usually a bad air flow meter will cause the “Check Engine” light to come on.
2.0L ‘98-0
#SN18010 . . . . . . . .$119.95
‘01-02
#SN19897 . . . . . . . .$389.95
1.8T ‘00-01
#SN19431 . . . . . . . .$209.95
‘00-04
#SN19506 . . . . . . . .$369.95
VR6®
#SN19416 . . . . . . . .$189.95
TDI®
#SN17844 . . . . . . . .$329.95
Cooling System
Premium Pentosin Antifreeze
Volkswagen® specifies phosphate/silicate free antifreeze in all their vehicles. Most “national brand” antifreeze does not meet VW’s specifications. German Pentosin antifreeze exceeds all of Volkswagen’s requirements and is neutral to metals, rubber parts and sealing materials. Mix 50/50 with distilled water for best results.
1.5 liter bottle #SN18726 . . . . .$13.95
Oil Coolers
Fits all 2.0 L gas. and 1.9 L diesel and TDI
#SN15359 . . . . . . . .$109.95
Flywheels
1.8T #SN19397 . . . . . . . .$599.95
TDI ‘98-00.5 #SN16704 . . .$399.95
TDI ‘00.5-05 . . . . . . .$449.95
“Standard” Flywheels
VR6 #SN17103 . . . . . . .$199.95
2.0 #SN19050 . . . . . . .$299.95
Clutch Kits
Engine 2.0
#SN18883 . . . . . . .$299.95
Engine 1.8T
#SN19399 . . . . . . .$369.95
Engine ‘98-00.5 TDI
#SN17081 . . . . . . .$329.95
ENGINE ‘00.5-05 TDI
#SN18156 . . . . . . .$359.95
Engine VR6
#SN17876 . . . . . . .$199.95
If yours is missing, it will cause the “check engine” light to come on. Replace it today!
The fuel pump is submerged in the tank on gasoline-engine models, and is only available as a complete assembly including the fuel gauge sending unit. Fits all ‘98-03 Beetle’s and all ‘99.5-03 Golf’s and Jetta’s .
#SN18639 . . . . . . .$269.95
USED - from 95.00
Injectors (Gas)
2.0 #SN39252 . . . . . . .$69.95
1.8T #SN19469 . . . . . . .$99.95
VR6 #SN18275 . . . . . . .$99.95
TDI Injection Pumps.
BRAND NEW!
New Beetle‘98-03, Golf,Jetta ‘99.5-03
Manual Transmission
#SN37359 . . . . . . .$1,295.95
Save $2,444.05 off dealer price
Automatic Transmission
#SN17865 . . . . . . .$1,595.00
Save $2,144.05 off dealer price!
TDI injectors are a different breed from the earlier ones. For one thing, they don’t screw into the head, they are held in by a separate clamp. Two, the #3 injector has a sensor that the brain uses to compare the actual start-of-injection to the anticipated start-of-injection, allowing fine adjustments to be made to the timing electronically. If this sensor fails, the electronics go into the “limp-home” mode and the “check engine” light comes on. Higher operating pressures also cause the nozzles to suffer greater erosion from dirty fuel-replace your fuel filter
regularly!
Manual Transmission
#1, 2, or 4 #SN18149 . . . . . . .$200.00
#3 #SN17893 . . . . . . .$284.95
Automatic Transmission
#1, 2, or 4 #SN17953 . . . . . . .$329.95
#3 #SN17893 . . . . . . $284.95
Remanufactured available too!!!
Water Pump
The water pump on 4-cylinder models is driven by the timing belt-it’s a good idea to always replace the timing belt when you replace the pump.
2.0 /1.8T #SN17856 . . . .$79.95
TDI #SN17931 . . . . . . . .$89.95
VR6 #SN13070 . . . . . . . .$84.95
Thermostat
2.0 /1.8T #SN19805 . . . .$19.99
TDI #SN17960 . . . . . . . .$13.95
VR6 #SN13298 . . . . . . .$22.95
Timing Belt
2.0 #SN16895 . . . . . . . .$37.95
1.8T #SN19432 . . . . . . . .$39.95
TDI #SN17033 . . . . . . . .$59.95
TDI Heavy Duty #SN19691. .$79.95