Golf 99.5-08/Jetta IV 99.5-08/New Beetle 98-08
TDI PERFORMANCE KITS
The stock TDI engine is great - with 90 hp and 155 lb/ft of torque it delivers enough power for most people. If you’re not “most people” the are upgrades available to boost your power and torque without much impact on fuel economy. Our kits are available in 3 pre-packaged stages.
Stage 1 is a matched set of larger orifice injectors, delivering a mild increase in power and easy installation.
Stage 2 adds a high performance injection pump, calibrated for greater fuel delivery.
Stage 3 adds a variable nozzle turbocharger, similar to the design found on ‘99.5 and later U.S. market TDIs. Requires modification to exhaust downpipe.
Stage 1 all ‘96-03
#SN19635 . . . . . . . Call
Stage 2 ‘96-99.5
#SN19382 . . . . . . . .$1595.00
Stage 3 ‘96-99.5
#SN19636 . . . . . . . .$989.98
Front Wheel Bearing Assemblies
Driver side #SN16901 . . . .$199.95
Passenger side #SN16903 . . . .$199.95
Wheel bearing kits without spindle
Golf/Jetta/Beetle ‘99.5-03
#SN17009 . . . . . . . .$69.95
Passat 4 cyl. ‘98-01.5
#SN19048 . . . . . . . .$69.95
Passat 4 cyl .01.5-05 (Incl. kit)
#SN19049 . . . . . . . .$79.95
Passat V6 (Incl. kit)
#SN19049 . . . . . . . .$79.95
Later Years . . . . . . . .CALL
Wheel bearing without kit--this is the wheel bearings and does not include the C Clips, nuts, etc. Just the bearing.
Golf/JettaIV ‘99-04, New Beetle ‘99.5-04
#SN13967 . . . . . . . .$44.95
Front Axle nut-VW says “Always replace.”
Golf/JettaIV ‘99-04, New Beetle ‘98-04 all, Golf/Jetta ‘93-99.5 with VS-6 only.
#SN19331 . . . . . . . .$4.15
(1) Clutch Kits
We stock brand-new OEM clutch kits for almost all late-model VWs, as well as flywheels (even dual-mass flywheels!) For far less than dealer prices.
Golf/Jetta ‘99.5-03, New Beetle ‘98-03
2.0L
#SN18883 . . . . . . . .$299.95
TDI
‘98-00.5
#SN17081 . . . . . . . .$329.95
‘00.5-05
#SN18156 . . . . . . . .$359.95
VR6
#SN17876 . . . . . . . .$199.95
1.8T
#SN19399 . . . . . . . .$369.95
Passat ‘98-03
1.8T
#SN18890 . . . . . . . .$379.95
V6
#SN18889 . . . . . . . .$379.95
(2) Flywheels
2.0L ‘99.5-03
#SN19050 . . . . . . . .$299.95
TDI‘96-99.5
#SN38999 . . . . . . . .$249.95
‘99.5-03
#SN16704 . . . . . . . .$444.95
VR6‘92-01
#SN17103 . . . . . . . .$199.95
Hose Kits
Golf/Jetta 2.0L
Manual Transmission
‘99.5-03
#SN20432 . . . . . . . . . . .CALL
‘01.5-04
#SN20433 . . . . . . . . . . .CALL
Auto Transmission
‘99.5-02
#SN20434 . . . . . . . . . . .CALL
Golf/Jetta TDI Manual Trans. . . . . .CALL
Window Regulators
We’ve seen a lot of window regulators fail. It seems like the
plastic in the actual lift mechanism fails, causing the window to drop down into the door. If you have power windows, you probably can hear the motor turning but nothing else happening. Sometimes there is a little warning (the window gets creaky as it moves up and down), other times there is none at all. power window regulators are available without the motor (you reuse yours). Manual window regulators are complete.
Golf/Jetta with manual windows ‘99.5-04
Left front
#SN17999 . . . . . . . .$99.95
Right front
#SN18000 . . . . . . . .$99.95
Left rear
#SN16642 . . . . . . . .$124.94
Right rear
#SN16643 . . . . . . . .$124.95
Recycled available cheaper--Call
Golf/Jetta with power windows ‘99.5-04 (w/o motor)
Left front
#SN16578 . . . . . . . .$99.99
Right front
#SN18283 . . . . . . . .$99.99
Recycled available cheaper--Call
Rear Wheel Bearing Assemblies
Rear wheel bearing on the newer cars are not available by themselves. Bearings come with the hub, ABS ring & “stub axle”, while Golf, Jetta and Beetle bearings consist of a hub, bearing and ABS ring. Easy to install, but more expensive than earlier cars.
Golf, Jetta, New Beetle ‘99.5-05
#SN18638 . . . . . . . .$119.95
Passat ‘98-03 (exc. 4 motion)
#SN19042 . . . . . . . .$139.95
Steel Oil Pan Kit
The solution for your cracked Aluminum oil pan. Fits all Golf/Jetta & New Beetle 2.0 & TDI, 99.5-05.
#SN20542 . . . . . . . .$179.95